OSHA Introduction PDF

10/20/2022 Disclaimer!!! I did not create this powerpoint. Any grammatical errors or misspellings was done by the federal government. Disclaimer!!! If you found this presentation BORING, remember I did NOT Write this Power P...

10/20/2022 Disclaimer!!! I did not create this powerpoint. Any grammatical errors or misspellings was done by the federal government. Disclaimer!!! If you found this presentation BORING, remember I did NOT Write this Power Point. Introduction & Understanding of OSHA 1  10/20/2022 What is OSHA ???????? OSHA IS The Occupational Safety and Health Administration 2  10/20/2022 Why Does OSHA Exists Because until 1970, no uniform or comprehensive provisions existed to protect against workplace safety and health hazards. On average, 15 workers die every day from work injuries. That’s approx., 5,600 workers annually. Approximately 4 million non-fatal job injuries and illnesses reported. When did OSHA Start? The Occupational Safety and Health Act of 1970 – 29 USC 653 Signed into law on December 29, 1970 by Richard M. Nixon. Act established OSHA (Occupational Safety and Health Administration), and its responsibility to provide worker safety and health protection. 3  10/20/2022 What is OSHA’s Mission? OSHA’s Mission To save lives To prevent injuries To protect America’s workers How does OSHA do that? 4  10/20/2022 Provide research Establish separate but dependent responsibilities and rights for employers/employees Maintain reporting & recordkeeping system Establish safety training progs Develop & enforce safety standards Evaluate and approve state safety programs. THE OSH ACT Is Also Known As The Williams Steiger Occupational Safety and Health Act of 1970 What does the OSH Act do? 5  10/20/2022 The OSHA Act Establishes specific responsibilities to Employer Establishes specific responsibilities to Employees OSHA Act Coverage Cont… It does not cover self employed persons Farms at which only immediate family members are employed Workplaces already protected by other govt agencies under other federal laws Federal and State OSHA The OSH Act covers employers and employees either directly through federal OSHA or through an OSHA approved state program. 24 States, plus Puerto Rico and the Virgin Islands have approved programs. 6  10/20/2022 What is the General Duty Clause Requirements of the General Duty Clause What is the General Duty Clause How does OSHA use the General Duty Clause? Steps company may take that go beyond compliance with OSHA standards 7  10/20/2022 How does OSHA Accomplish its Mission OSHA Uses 3 Basic Strategies To Help Reduce Injury and Death on the Job Strong, fair, and effective enforcement. Outreach, education, and compliance assistance. Partnerships and other cooperative programs. Workplace Inspections Authority Normally notice is not given Employee’s representative must be informed 8  10/20/2022 Notice of Inspections OSHA generally conducts inspections without advance notice. In fact, anyone who alerts an employer in advance of an OSHA inspection can receive a criminal fine of up to $1,000, or a six-month jail term or both. Under special circumstances, OSHA may give the employer advance notice of an inspection—but no more than 24 hours. These special circumstances include: Imminent danger situations, which require correction immediately. Inspections that must take place after regular business hours, or require special preparation. Cases where OSHA must provide advance notice to assure that the employer and employee representative or other personnel will be present. Situations in which OSHA determines that advance notice would produce a more thorough or effective inspection. OSHA Inspection Priorities Imminent Danger or any condition where there is reasonable certainty that a danger exists that can be expected to cause death or serious physical harm immediately. Catastrophes and fatal accidents resulting in the death of any employee or the hospitalization of three or more employees. 9  10/20/2022 OSHA Inspection Priorities Employee complaints involving imminent danger or an employer violation that threatens death or serious physical harm. Referrals from other individuals, agencies, organizations, or the media. Planned, or programmed, inspections in industries with a high number of hazards and associated injuries. Follow-ups to previous inspections. Inspections Process A typical OSHA on-site inspection includes four stages: 1. Presentation of inspector credentials. 2. An opening conference. 3. An inspection walk-around. 4. A closing conference. Opening Conference In the opening conference, the compliance officer: Explains why OSHA selected the establishment for inspection. Obtains information about the establishment. Explains the purpose of the visit, the scope of the inspection, walk-around procedures, employee representation, employee interviews, and the closing conference. Determines whether an OSHA funded consultation is in progress or whether the facility has received an inspection exemption. If so, the compliance officer usually terminates the inspection. 10  10/20/2022 Inspection Walk-around After the opening conference, the compliance officer and accompanying representatives proceed through the establishment, inspecting work areas for potentially hazardous working conditions. The compliance officer will discuss possible corrective actions with the employer. OSHA may consult, at times privately, with employees during the inspection walk- around. Inspection Walk-around An inspection walk-around may cover only part of an establishment – particularly if the inspection resulted from a specific complaint, fatality, or catastrophe, or, is part of a local or national emphasis program. Other inspections may cover the entire facility, “wall to wall.” Trade secrets observed by the compliance officers are kept confidential. Federal employees who release confidential information without authorization are subject to a $1,000 fine, one year in jail, or both, and removal from office or employment. Record Reviews The compliance officer checks posting and recordkeeping practices, including whether the employer has: Maintained records of deaths, injuries, and illnesses; Posted OSHA’s Summary of Work-Related Injuries and Illnesses (OSHA 300A) from February 1 to April 30. Prominently displayed the OSHA “It’s The Law” poster (OSHA 3165). The compliance officer also examines records, where required, of employee exposure to toxic substances and harmful physical agents. 11  10/20/2022 OSHA Citations Citations inform the employer and employees of: Regulations and standards the employer allegedly violated. Any hazardous working conditions covered by the OSH Act’s general duty clause. The proposed length of time set for abatement of hazards. Any proposed penalties. Penalties Only the OSHA area director has the authority to tell the employer what penalties the agency will propose. OSHA has up to six months following an inspection to issue a final report. After reviewing the full inspection report, the OSHA area director will: a) Issue citations without penalties. b) Issue citations with proposed penalties. c) Determine that neither are warranted. Penalties Cont…. Serious Other than serious Willful Repeat Failure to Abate 12  10/20/2022 Serious Violations A violation where there is substantial probability that death or serious physical harm could result and that the employer knew, or should have known, of the hazard. OSHA may propose a mandatory penalty of up to $7,000 for each serious violation. Other than Serious A violation that has a direct relationship to job safety and health, but probably would not cause death or serious physical harm. OSHA may propose a penalty of up to $7,000 for each other-than-serious violation. Willful A violation that the employer intentionally and knowingly commits or a violation that the employer commits with plain indifference to the law. The employer either knows that what he or she is doing constitutes a violation, or is aware that a hazardous condition existed and made no reasonable effort to eliminate it. OSHA may propose penalties of up to $70,000 for each willful violation, with a minimum penalty of $5,000 for each willful violation 13  10/20/2022 Repeat A violation of any standard, regulation, rule, or order where OSHA finds a substantially similar violation during a re-inspection. OSHA may propose penalties of up to $70,000 for each repeated violation. To be the basis of a repeat citation, the original citation must be final. Failure to Abate OSHA may propose an additional penalty of up to $7,000 for each day an employer fails to correct a previously cited violation beyond the prescribed abatement date. Other Potential Penalties Violating posting requirements can bring a civil penalty of up to $7,000. (OSHA does not fine for failing to post the “It’s The Law” poster (OSHA 3165). Falsifying records, reports, or applications, upon conviction in a court, can bring a criminal fine of $10,000 or up to six months in jail, or both. Assaulting a compliance officer or otherwise resisting, opposing, intimidating or interfering with a compliance officer in the performance of his or her duties is a criminal offense. Anyone convicted of such an action is subject to a criminal fine of not more than $5,000 and imprisonment for not more than three years. 14  10/20/2022 Adjustments to Proposed Penalties The agency may adjust a penalty downward depending on the employer’s good faith (demonstrated efforts to comply with the OSH Act), history of previous violations, and size of business. When the adjusted penalty amounts to less than $100, OSHA does not propose any penalty. For serious violations, OSHA may also reduce the proposed penalty based on the gravity of the alleged violation. No good faith adjustment will be made for alleged willful violations. Criminal Penalties An employer who is convicted in a criminal proceeding of a willful violation of a standard that has resulted in the death of an employee may be fined up to $250,000 (or $500,000 if the employer is a corporation) or imprisoned up to six months, or both. A second conviction doubles the possible term of imprisonment. 15  10/20/2022 Contesting a Citation Informal conference request may be made prior to deciding to contest – Obtain a better explanation of the violations cited – Obtain a more complete understanding of the specific standards which apply Contesting Cont… Negotiate and enter into an informal Settlement Agreement Discuss ways to correct the violations Discuss problems with the abatement dates Discuss problems concerning employee Resolve disputed citations/penalties Review of Notices of Contest 16  10/20/2022 Reviews of Notices of Contest Notices of Contest may be reviewed by the Occupational Safety and Health Review Commission (OSHRC). The commission is an independent federal agency created by the OSH Act to decide contested OSHA citations and penalties. It is not associated with OSHA or the Department of Labor. Reviews of Notices of Contest The commission will assign an administrative law judge to hear the case. The administrative law judge may: a) Find the contest legally invalid and disallow it, or b) Set a hearing for a public place near the employer’s workplace. The employer and the employees have the right to participate in the hearing. From there, appeals would go to the U. S. Court of Appeals. OSHA Recordkeeping Requirements 29 CFR 1904 OSHA’s reporting and recordkeeping regulations require employers to: Maintain records in each establishment of occupational injuries and illnesses as they occur, and make those records accessible to employees. Keep injury and illness records and post from February 1 through April 30 an annual summary of occupational injuries and illnesses for each establishment. A company executive must certify the accuracy of the summary. 17  10/20/2022 Employer Requirements Record any fatality regardless of the length of time between the injury and the death. Provide, upon request, pertinent injury and illness records for inspection and copying by any representative of the Secretaries of Labor or HHS, or the state during any investigation, research, or statistical compilation. Comply with any additional recordkeeping and reporting requirements in specific OSHA standards. Determining Which Work-Related Illnesses and Injuries to Record 18  10/20/2022 Employers With Multiple Worksites Employers must keep injury and illness records for each establishment. OSHA defines an establishment as a “single physical location where business is conducted or where services are performed.” An employer whose employees work in dispersed locations must keep records at the place where the employees report for work. In some situations, employees do not report to work at the same place each day. In that case, records must be kept at the place from which they are paid or at the base from which they operate. OSHA 301, Injury and Illness Incident Report Each employer must complete the OSHA 301 form within seven calendar days from the time the employer learns of the work-related injury or illness. This form includes more data about how the injury or illness occurred. Employees and former employees are guaranteed access to their individual OSHA 301 forms. Employee representatives will be provided access to the “information about the case” section of the OSHA 301 form in establishments where they represent employees. OSHA Form 300A Summary of Work-Related Injuries and Illnesses This form was created to make it easier to post and calculate incident rates. Employers must post copies of the previous year’s records no later than February 1 and keep them in place through April 30. 19  10/20/2022 OSHA Outreach OSHA Partnership 20 10/20/2022 21